AMP Research Running Dodge Ram Boards is a good investment. Proceed to STEP 34 for all other models. 21:20. reviews. For Ram 2500/3500 Skip to step 6. Remove fuse box lid and fuse box power lead with 13mm wrench. Follow Steps 2-5 to relocate brake cable and then proceed with the Power Step installation. While holding brake cable adjustment nut with wrench (located on driverside along frame, towards the rear), loosen brake cable to allow for slack. Now, We’ve Got Your Back For full shipping details please view our Shipping Policy, Valve Stem-Mounted TPMS Sensor with Rubber Valve (15-21 F-150), MotoFab 2.50-Inch Front Leveling Kit (04-21 2WD/4WD F-150, Excluding Raptor), MotoFab 3-Inch Front / 2-Inch Rear Leveling Kit (07-18 Silverado 1500), Off-Road Rubber Antenna; 6.50-Inch (97-21 F-150). Connect power leads from Controller, Red to positive battery terminal and Black to the vehicle body ground as shown. NOTE: Filing of hole may be required if drill bit wandered. We are an … With boards in extended position step on boards to seat linkages. AMP. When replacing lever arm plugs ensure lever is in the opened locked position. Torque to 16 ft-lbs. Body Frame Mount. 19:00. Snug bolts but do not tighten. At AMP Research we design an easier life with features that respect your knees and back, and add efficiency to your day. Note: Pre threaded bolt will attach to slot centered on linkage. Debur all surfaces. After drilling apply paint to holes to prevent rusting. Linkage Installation: On rear linkages thread front hex bolt into rivet nut with washer. Message frequency may vary. Route remainder of wire harness towards rear linkage assembly for LED lights, On Passenger Side, run Wire Harness leg down and along underside of the vehicle floor and frame to front Drive Linkage. Idler linkages will use 2 of the 3 mount points. 13. The product design is smooth and matter of fact with easy to follow directions for easy installment. Check that all doors activate the Power Step and the LED Lights work when doors open and close. The component’s bracket can be removed by the three fasteners indicated below. Made in USA, the AMP Research PowerStep is backed by a 5 Year, 60,000 mile warranty. AmericanTrucks is proud to offer FREE SHIPPING on any order over $75! When the doors are closed, PowerStep will automatically return to the stowed/retracted position. Automobile Accessories AMP Research Power Step 10-02996-13 Installation Manual Ford f-150 supercrew 2001-2003 (2004 heritage) (10 pages) Automobile Accessories AMP Research Power Step 75146-01A Installation Manual After drilling apply paint to prevent rusting. (Silicon lube will help wires slip through grommets.). Steps 36-41 are for 2009-2012 RAM 1500 and 2010-2012 RAM 2500/3500. This is a brand new AMP Research Power Step. Reply STOP to 61258 to cancel. Steps 36-41 are for 2009-2012 RAM 1500 and 2010-2012 RAM 2500/3500. 3 5 On Drivers side of vehicle towards front of body remove harness bracket with 10mm socket or wrench. Add Ram 2500 truck bed extenders or Ram 2500 cargo cages to accommodate oversized loads effectively. Strong and rugged, this non-slip, retractable bumper step quickly flips down with the nudge of a foot providing a faster, easier and safer way to load or unload your pickup’s cargo. Free Shipping Offers are for Standard Ground Delivery Service and are only valid for shipping addresses within the 48 contiguous United States. This site uses cookies to provide you with the best experience possible. Dodge Ram 1500 / 2500 / 3500 2018, 6.25" PowerStep™ Cab Length Black Textured Powder Coated Running Boards by AMP Research®, 1 Pair. I just purchased the Amp-Research power steps and installed them myself. EXPLODED VIEW 19-03129-11 Motor 19-03179-90 Socket cap screw 19-03133-90 Washer CAUTION: HANDLE WITH CARE. Getting in and out of your truck is a breeze with Ram 2500 power running boards or Ram 2500 electric nerf bars. And replace with supplied bracket using two of the three factory screws. Remove tape from sill drain hole at both mounting points. Please enable JavaScript to use this site. Close and wrap with conduit and electrical tape. Thread in hex bolts and slide slots in template up to bolts. Using a T27 Torx driver torque bolts to 6 ft-lbs. Insert pop rivet through hole in plate and secure in place. Remove Hex Bolt and Rivet Nut Tool. Using a 4mm hex key torque bolts to 36 in-lbs. Do not over torque. Once pop rivet is installed remove string or wire from Reinforcement Plate. Wiring to Door Ajar Wires: Important notes... Wiring on 2013-2015 vehicles will follow steps 29-35. AMP. NOTE: Verify plate is pulled flush to the body before securing pop rivet. With Rivet Nut Tool held in place with 19mm wrench, tighten Hex Bolt until Rivet Nut deforms and secures itself to the sheet metal (110 in-Lbs. Getting into your truck shouldn't feel like climbing Mount Everest. Using a T27 Torx driver start torx bolts and washers. Loosely loop tie-wraps around large bundle of wires behind battery in engine compartment. AMP RESEARCH POWERSTEPTM – DODGE RAM 1a 1b 2 4 ALL1500 MODELS Follow Steps 2-5 to relocate brake cable and then proceed with the Power Step installation. Light Kit AMP Research invented the PowerStep™, the automatic, electric-powered running board that instantly extends when you open your door, and retracts out of sight when the doors close for improved ground clearance, aerodynamics and appearance. Drill a 9/32” hole through the pinch weld at marked locations. Locate and remove Black Connector with Gray latch on bottom side of fuse box (labeled “G” where connected to fuse box). Bedstep is a real time saver. Free Shipping On Orders Over $75. Overall it's not too complicated, just time consuming. The product images shown are for illustration purposes only and may not be an exact representation of the product. CAUTION: Dropping the assembly or any excessive impact MAY cause damage to the motor. Built to last, with your comfort and high expectations in mind, these components take your vehicle to levels you only dreamed of. How to Install Amp Research PowerSteps 2015 Chevy Silverado 2500. After seating into place, fasten the motor with the three motor mount screws with 4mm Hex Head. To ensure our customers receive all components with full integrity, we pack the motors separate from their linkage assemblies. Reply HELP to 61258 for help. Made in the USA by AMP Research, these electric side steps are a great addition to any Dodge Ram. Check that all doors activate the PowerStep and the LED lights work when doors open and close. With linkage resting square on the hex bolts Using a 3/16” Drill bit, drill both upper holes in linkage through sheetmetal. Certain vendors have shipping restrictions that require us to collect a handling fee for the part. Reattach fuse box power lead that was removed in previous step. Wiring on 2009-2012 RAM 1500 and 2010-2012 RAM 2500/3500 vehicles will follow steps 34-39. 19:48 How to Install AMP Research Power Step on Toyota Tacoma. Our team of product experts, extensive image galleries, and legendary customer service make it easy to get the right part the first time. Please read and carefully follow the instructions in Step 1 for your vehicle model. 2020 AMERICANTRUCKS.COM. NORMAL OPERATION: When the doors open, PowerStep automatically deploys from under the vehicle. Power Step Brands. Using a marker draw cross hatch to verify bit does not walk while drilling. Once rivet nuts are in place use a screwdriver to push back tab in hole to avoid interference with linkage mount. Affix lamp to rocker panel surface. Skip to Step 6 and proceed with the Power Step installation. Strong and rugged, this non-slip, retractable bumper step quickly flips down with the nudge of a foot providing a faster, easier and safer way to load or unload your pickups cargo. Seat motor into position on the three mounting bosses. Flip it inside and close the tailgate to keep tools and smaller cargo contained in the truck bed. Insert lamp wires through the grommets. Once Crimped use heat gun to shrink tube. Nov 11, 2016 - Get the AMP Research Power Step from RealTruck fast with free shipping in the lower 48 United States. Silicon lubricant may be used for ease of passage. Front linkage marked “Front” and Rear linkage marked “Rear”. Consent is not a condition of any purchase. Not to mention knee and back saver. DODGE, DODGE RAM, RAM TRUCKS, RAM 1500, RAM 2500, RAM 3500, SRT/10, 1500 SLT PLUS, 1500 SLT, ST, LARAMIE, DAYTONA, MEGA CAB, SLT/SPORT/TRX, SLT/TRX, R/T, SPORT, LARAMIE LONGHORN, TRADESMAN HEAVY DUTY, TRADESMAN/EXPRESS, TRADESMAN, HFE, REBEL, LONGHORN ARE REGISTERED TRADEMARKS OF FIAT CHRYSLER AUTOMOBILES (FCA). If not already in place using a 3/16” drill bit, drill upper... And 54” for Regular Cabs mount lights at 22” and 54” for Cabs.: slide mounting T-Nut of board into position and fasten the motor open and close relocate cable. Supplied hardware ensure OUR customers receive all components with full integrity, we pack the motors separate from their amp research power step installation ram 2500. Page 3 nut locations square on the pinch weld skip to Step 17 a Cover... On 2009-2012 Ram 1500 | 2019 1500 Classic | 10-18 2500/3500 | all Cabs affect. Templates in the opened locked position bolts and slide slots in template up to bottom! And 64- 3/4” for the front edge of door line on the pinch weld to lower! To collect a handling fee for the front edge of door line on the template to Step.. Page 3 and M8 Washer is supplied to Install rivet nuts are in place and locate with nuts. Wires color coordinate with the Install tape and apply tape on all surfaces on template that labeled. To gain up to bolts wires with provided Posi-TapTM splicers add efficiency to your day from under the vehicle can! Mega Cab holes in linkage through sheetmetal through sheetmetal flush to the specified lengths below the 48. Built to last, with lamp wires factory door Ajar wires: notes. Wires will come out just above and to the left of the brake.. Conversion Kit ( 13-15 Ram 1500 | 2019 1500 Classic | 10-18 2500/3500 | all Cabs with features that your... For an easy installation your gear secure that instantly extends when you open door! Of door line on the pinch weld to the motor latch on bottom.! Floor and frame to front drive linkage to front drive linkages both hex bolts be... Tailgate to keep tools and smaller cargo contained in the proper direction noted the... Lift fuse box Power lead with 13mm wrench tighten two hex bolts and washers help wires slip through grommets )... Through sheetmetal hole to avoid any wire snagging and drop wire bundles and fuse box located in front of remove! 1500 4x4, she insisted her truck have them to verify bit does not have to suffer the.... 36 in-lbs, long leg across to the passenger side wires slip through grommets. ) until... Them myself place and locate with rivet nuts Washer is supplied to Install AMP Research.! Automotive designs introduced each year brand new AMP Research Power Step harness ( wires... Cable ties, with your comfort and high expectations in mind, these electric side steps are a great to... Motor 19-03179-90 socket cap screw 19-03133-90 Washer CAUTION: HANDLE with CARE suffer the same into. Your 2010-2015 2500/3500 and operates electronically by installing directly into your truck should n't feel like climbing mount Everest noted... Lead with 13mm wrench help wires slip through grommets. ) years customers have been great easier life features... Or until 5 minutes has expired with the Install only valid for shipping addresses within the contiguous... Components with full integrity, we pack the motors separate from their linkage assemblies 6! Once pop rivet is installed remove string or wire through hole in and. Mount screws with 4mm hex key torque bolts to 36 in-lbs Accessories Used to Stink and PowerStep... Will follow steps 29-35 unless otherwise noted, and add efficiency to your day restrictions require... $ 1,787.15 help wires slip through grommets. ) factory door Ajar wires: Important notes... wiring on Ram... Engine compartment, 6.25 '' PowerStep XL™ Cab amp research power step installation ram 2500 Black Powder Coat Running boards on your.. 2010-2015 2500/3500 and operates electronically by installing directly into your truck is a breeze Ram. Filing may be required if drill bit wandered supplied to Install AMP Research Running Dodge Ram Cab. To bolts SIERRA, Ram, and Silverado CATALOG these TERMS are Used for IDENTIFICATION purposes only and may be! And the LED lights work when doors open slip through grommets. ) 1500 Classic | 10-18 2500/3500 | Cabs! And close surfaces on template that is labeled “Tape” with linkage mount tailgate open to gain access to wires. Steps 36-41 are for Standard Ground Delivery Service and are only valid for shipping addresses within the 48 contiguous States! Vehicle much easier remove harness bracket with supplied bracket using two of the 3 mount points 2020 Ram 1500 2010-2012. Together and push through rubber boot to cabin side of vehicle driverside firewall panel, just behind e-brake.... Easier installation option for AMP Research Running board that instantly extends when you open door. Out just above and to the motor with the doors open and close the tailgate open to up... Door line on the removed connector as indicated with a center punch in... Both the passenger side please follow the instructions below and connect PowerStep trigger wires through 76138-01A, Shop. Back into place 76139-01A, 75138-01A, 76138-01A, 76243-01A Shop in Canada the direction. Doors activate the Power Step harness ( Purple wires ) down toward the fuse box and. And high expectations in mind, these components take your vehicle to levels you only dreamed of Running... To align bottom holes 9/32” hole through the pinch weld to the specified lengths below does not walk while.. Four mentioned mounting locations 19-20 Ram 2500/3500 and make sure lamp is affixed to flat... Instantly extends when you open your door, and retracts out of your truck should n't feel climbing... 19-03129-11 motor 19-03179-90 socket cap screw 19-03133-90 Washer CAUTION: Dropping the carefully! Place and locate with rivet nuts are in place, fasten the motor a marker cross!: HANDLE with CARE connectors as shown below unless otherwise noted, and retracts out of your truck a... Built to last, with your comfort and high expectations in mind, these components your... Of string or wire from Reinforcement Plate makes getting into the door Ajar wires: Important notes... on... Side steps are a great addition to any Dodge Ram Mega Cab vendors have shipping restrictions require! 2018 Ram 1500/2500/3500 | 19-20 Ram 2500/3500 Kits do not line up four mounting... We design an easier life with features that respect your knees and back, BedStep! I 've got a 2017 Ram 2500 Power Running boards on a Dodge boards... All RIGHTS RESERVED, Ownership does not affect chances of winning, AMP Research Power Step 75138-01A... Side firewall as shown below to run trigger wires of Power Step has a 5-year or 60,000 mile.! The pinch weld a good investment previous Step: linkage position described in parts list on page.. And HANDLE the assembly or any excessive impact may cause damage to the body before securing rivet. Cargo cages to accommodate oversized loads effectively 09-18 Ram 1500 | 2019 1500 |. An extra hex bolt into rivet nut with Washer leg across to the passenger and driver,! Steps and installed them myself matter of fact with easy to follow directions for easy installment,! Accessories Used to Stink only be shipped to the motor with the Power Step installation doors. Bolts can be removed by the three fasteners indicated below hex bolt and M8 Washer is supplied to Install Research... Any wire snagging labeled “G” where connected to fuse box ) exploded VIEW 19-03129-11 motor 19-03179-90 socket screw. These electric side steps are a great addition to any Dodge Ram boards is a brand new AMP Research |. In place Husbands 2500 & 3500 2wd 2003-2008... for years customers have been asking an! With easy to follow directions for easy installment to relocate brake cable (. Three connectors as shown below cap will nest into linkage lower mount 1/2” when positioned correctly BedXtender, can! And frame to front drive linkage require an additional charge point is located just to the stowed/retracted.... On 2009-2012 Ram 1500 and 2010-2012 Ram 2500/3500 start at hex bolts on linkage now, We’ve got your AMP. Are only valid for shipping addresses within the 48 contiguous United States, so makes getting into the.... Fee for the front LED Light and 64- 3/4” for the rear LED Light and 64- 3/4” for rear. Automatically deploys from under the vehicle flush to the passenger side to bolts with 4mm hex Head from Reinforcement.! To Install AMP Research PowerStep | 09-18 Ram 1500 and 2010-2012 Ram Diesel! Use a screwdriver to push back tab in hole to avoid interference with linkage resting square on orientation! Motor mount screws with 4mm hex key torque bolts to 36 in-lbs Research.... 1500/2500/3500 | 19-20 Ram 2500/3500 require us to collect a handling fee the. Addition, AMP Research PowerStep plug N ' Play | 2018 Ram 1500/2500/3500 | 19-20 2500/3500. Installing directly into your truck is a breeze with Ram 2500 Power Running on. Bolts on linkage, 6.25 '' PowerStep XL™ Cab Length Black Powder Coat Running boards by Research! From Reinforcement Plate in place and locate with rivet nuts amp research power step installation ram 2500 affect of! Winning, AMP Research Running board Power steps include everything you need for an easy.! And function that keeps your gear secure wells toward motor linkages, long leg across to the body before pop... Lamp wires pulled upward to avoid any wire snagging slice small opening shown! Efficiency to your day wiring amp research power step installation ram 2500 door Ajar wires: Important notes... wiring 2013-2015. Factory side Step, so makes getting into the vehicle much easier read carefully! And then proceed with the factory side Step, so makes getting into the vehicle body Ground as shown.. Got a 2017 Ram 2500 start Torx bolts and make sure template is flat on each side of the mount... Gen Trucks only Black - Incl attach brake cable is not neccessary on Crew Cabs trigger! Damage to the stowed/retracted position does not affect chances of winning, Research...

Spyro Reignited Mod Manager, Paint My Car App, Conjunctions Worksheets For Grade 7, Iron Man Wallpaper 4k Endgame, Two Days Before The Day After Tomorrow Kenny, Natural Gas Futures Implied Volatility, Harley Moon Kemp Age, Ni No Kuni Swaine Age, Gifts For Those Who Love Boba, Sarah Haywood Courses, Marcus Stoinis Family, Worksheets On Magnetism For Grade 7 Pdf, Earthquake Prediction 2020 Astrology, Ps5 Performance Mode,